Efektivitas Kapur Tohor Terhadap Peningkatan Ph Dan Penurunan Kadar Logam Fe Dan Mn Di Settling Pond 11 PT. Alam Jaya Pratama Site Bara Kumala Sakti Kecamatan Loa Kulu, Kabupaten Kutai Kartanegara, Provinsi Kalimantan Timur

Jovanda Ego Prisitama; Henny Magdalena; Shalaho Dina Devy

Jovanda Ego Prisitama Universitas Mulawarman
Henny Magdalena Universitas Mulawarman
Shalaho Dina Devy Universitas Mulawarman

Abstract

The settling pond is the final location where water comes from the Pit, Sump, Disposal and run-off water around the mining location at PT. Alam Jaya Pratama site Bara Kumala Sakti. Water quality in settling pond that does not meet the Mining Activity Waste Water Quality Standards can be managed using chemicals, one of which is Calcium Oxide (CaO). The need for Calcium Oxide can be determined after knowing the most effective dose in the settling pond. Calcium Oxide functions to neutralize pH and reduce metal levels (Fe and Mn) in settling ponds. Based on facts in the field, the poor water quality for the surrounding environment is due to the management period being too long and the efficiency of using Calcium Oxide incorrectly. So that the quality of the water released can meet the standards, regular monitoring and testing of the water quality in the settling pond is required with the final aim of the water output being in accordance with the standards and the amount of Calcium Oxide needed in Settling Pond 11 can also be known. From the results of initial measurements on water samples at Inlet Settling Pond 11 was obtained an average pH of 3,25; levels of Fe 1,61 mg/L; levels of Mn 2,81 mg/L are below standard. By testing using the titration method, the average optimum dose for increasing pH and reducing metal levels was 1 mg/L. After each sample went through a titration test, the average was obtained, namely: pH 7,32; levels of Fe 0,46 mg/L; and levels of Mn 1,63 mg/L. From this average dose, the need for Calcium Oxide is 223,32 kg/month. The comparison of Calcium Oxide usage per month between actual and calculated is 500 kg : 223,32 kg. The recommendation from this comparison is that these results can be taken into consideration to optimize the use of Calcium Oxide in Settling Pond 11.

References

[1] Adha, Chairul Wahyu., Ramli, Muhammad & Thamrin, Meinarni. 2017. Analisis Efektivitas Kapur Tohor dan Zeolit Untuk Peningkatan pH dan Penurunan Kandungan Logam Fe dan Cu Pada Pengolahan Air Asam Tambang. Prosiding Seminar Nasional Teknologi IV. Jurusan Teknik Pertambangan. Universitas Hasanuddin. Makassar. ISSN: 2598-7410. (Hal 43-50).
[2] Baramsyah, Haqul., Mutia, Febi & Andani, Puti. 2020. Perencanaan Kolam Pengendapan pada Sistem Penyaliran Area Disposal Penambangan Batubara (Studi Kasus: PT Mifa Bersaudara, Aceh Barat). Seminar Ilmiah Nasional Air Asam Tambang ke-6. Universitas Syiah Kuala. Aceh. (Hal 5).
[3] Chin, David A. 2013. Water Quality Engineering in Natural Systems: Fate and Transport Processes in the Water Environment, Second Edition. John Wiley & Sons, Inc. New Jersey. ISBN: 978-1-118-07860-0. (Hal 5-7).
[4] Faisal, Ahmad., Syarifudin. 2014. Dosis Optimum Larutan Kapur Untuk Netralisasi pH Air Limbah Penambangan Batubara. Jurnal Kesehatan Lingkungan Vol 11 No 1. Poltekkes Kemenkes Banjarmasin. Jurusan Kesehatan Lingkungan. Banjarbaru. ISSN: 2581-0898. (Hal 187).
[5] Hijriani, Astria., Muludi, Kurnia., Andini, Erlina Ain. 2016. Implementasi Metode Regresi Linier Sederhana pada Penyajian Hasil Prediksi Pemakaian Air Bersih PDAM Way Rilau Kota Bandar Lampung dengan Sistem Informasi Geografis. Jurnal Informatika Mulawarman Vol 11 No 2. Jurusan Ilmu Komputer. FMIPA. Universitas Lampung. Bandar Lampung. ISSN: 1858-4853. (Hal 38).
[6] Kiswanto., Susanto, Heru., Sudarno. 2018. Karakteristik Air Asam Tambang Batubara Di Kolam Bekas Tambang Batubara PT. Bukit Asam (PTBA). Seminar dan Konferensi Nasional IDEC. Surakarta. ISSN: 2579-6429. (Hal 4-5).
[7] Peraturan Daerah Provinsi Kalimantan Timur Nomor 2 Tahun 2011 Tentang Pengelolaan Kualitas Air dan Pengendalian Pencemaran Air. (Hal 178).
[8] Peraturan Menteri Lingkungan Hidup dan Kehutanan Nomor 5 Tahun 2022 Tentang Pengolahan Air Limbah Bagi Usaha dan/atau Kegiatan Pertambangan dengan Menggunakan Metode Lahan Basah Buatan. (Hal 41).
[9] Putri, Fairus Atika Redanto. 2020. Kajian Teknis Sistem Penyaliran Tambang Batubara pada Tambang Terbuka di PT. X. Jurnal Iptek Media Komunikasi Teknologi. Institut Adhi Tama Surabaya. ISSN: 1411-7010. (Hal 60-61).
[10] Tandiarrang, Jenita., Devy, Shalaho Dina & Trides, Tommy. 2016. Studi Perbandingan Penggunaan Tawas Dan Kapur Padam Pada Pengolahan Air Asam Tambang Di PT. Kaltim Diamond Coal Kecamatan Loa Kulu Kabupaten Kutai Kartanegara Kalimantan Timur. Jurnal Teknologi Mineral Vol 4 No. 1. Jurusan Teknik Pertambangan. Fakultas Teknik. Universitas Mulawarman. Samarinda. ISSN: 2252-7605. (Hal 26-30).